自上料搅拌车厂家直销

品质创造未来,爱上中科聚峰造

全国咨询热线
400-879-1999
当前位置:首页 »新闻中心 » 公司新闻全自动搅拌车应遵守的操作规范

全自动搅拌车应遵守的操作规范

来源:https://www.jfjiaobanche.com 浏览:0发表时间:2022-10-21
全自动搅拌车若不进行操作,将会引起翻车、液压泵、马达、减速机过快磨损甚出现严重后果,下面全自动搅拌车厂家根据使用全自动搅拌车应遵守的操作规范为大家作出了如下介绍。
If the full automatic mixer is not operated safely, it will cause overturning, hydraulic pump, motor, reducer to wear too fast or even have serious consequences. The manufacturer of the full automatic mixer has made the following introduction according to the safety operation specifications that should be followed when using the full automatic mixer.
1、拌筒的旋转方向应符合箭头指示方向,如不符实,应更正电机接线。
1. The rotation direction of the mixing drum shall conform to the direction indicated by the arrow. If not, the motor wiring shall be corrected.
2、全自动搅拌车应实施二级漏电保护,上班前电源接通后,仔细检查,经空车试转认为合格,方可使用。试运转时应检验拌筒转速是否合适,一般情况下,空车速度比重车(装料后)稍快2~3转,如相差较多,应调整动轮与传动轮的比例。
2. The fully automatic mixer shall be provided with secondary leakage protection. After the power is turned on before going to work, it shall be carefully checked. It can only be used after passing the no-load trial run. During the test run, check whether the rotating speed of the mixing drum is appropriate. Generally, the speed of the empty car is 2~3 revolutions faster than that of the car (after loading). If there is a large difference, adjust the ratio of the driving wheel to the driving wheel.
3、搅拌车应设置在平坦的位置,用方木垫起前后轮轴,使轮胎搁高架空,以免在开动时发生走动。
3. The mixer truck shall be set at a flat position. Square wood shall be used to pad the front and rear axles, so that the tires are kept overhead to avoid walking when driving.
全自动搅拌车厂家
4、检查传动离合器和制动器是否灵活可靠,钢丝绳有无损坏,轨道滑轮是否良好,周围有无障碍及各部位的润滑情况等。
4. Check whether the transmission clutch and brake are flexible and reliable, whether the wire rope is damaged, whether the track pulley is in good condition, whether there are obstacles around and whether the lubrication of each part is good.
5、当混凝土搅拌完毕或预计停歇1h以上,除将余料出净外,应用石子和清水倒入抖筒内,开机转动,把粘在料筒上的砂浆冲洗干净后全部卸出。料筒内不得有积水,以免料筒和叶片生锈。同时还应清理搅拌筒外积灰,使机械保持清洁完好。
5. When the concrete has been mixed or is expected to stop for more than 1h, in addition to discharging the remaining materials, the stones and water shall be poured into the trembling cylinder, the machine shall be started to rotate, and the mortar stuck on the cylinder shall be washed clean and then discharged. There shall be no accumulated water in the barrel to avoid rusting of the barrel and blades. At the same time, the dust accumulated outside the mixing drum shall be cleaned to keep the machinery clean and in good condition.
6、开机后,经常注意搅拌机各部件的运转是否正常。停机时,经常检查搅拌机叶片是否打弯,螺丝有否打落或松动。
6. After startup, always pay attention to whether all parts of the mixer operate normally. During shutdown, always check whether the blades of the mixer are bent and whether the screws are fallen or loose.
7、下班后及停机不用时,应拉闸断电,并锁好开关箱,以确保。
7. After work and when the machine is not in use, switch off the power and lock the switch box to ensure safety.
以上就是使用全自动搅拌车应遵守的操作规范,想必大家在以后的使用中会更加小心谨慎了,想了解更多资讯么?请继续关注我们https://www.jfjiaobanche.com
The above are the safety operation specifications that should be followed when using the fully automatic mixer. I think you will be more careful in future use. Do you want to know more? Please continue to follow us https://www.jfjiaobanche.com 。