购买搅拌车之后一定先做这些事情！
1、新车开始使用时，须进行检查和试车，正常时，方可正式使用。
1. When the new car is put into use, it must be comprehensively inspected and tested. It can be officially used only when it is normal.
2、输送混凝土的容量，质量及塌落度应符合规定。
2. The capacity, quality and slump of transported concrete shall meet the regulations.
3、搅拌车在露天场地停放时，装料前应先将搅拌筒反转，把筒内的积水（或雨水）和杂物卸出，以保证运送混凝土的质量。
3. When the mixer truck is parked in the open field, the mixing drum shall be reversed before loading, and the ponding (or rainwater) and sundries in the drum shall be unloaded to ensure the quality of concrete transportation.
4、在出料斗、卸料溜槽旁工作时，要配带防护用品。不要接近料斗及搅拌口,也不要向内窥看,更不得用手去摸旋转的搅拌筒。
4. When working near the discharge hopper and discharge chute, wear protective articles. Do not approach the hopper and mixing port, do not look inward, and do not touch the rotating mixing drum with your hand.
5、在公路上行驶时，加长溜槽须翻转放置在卸料溜槽上用挂钩挂牢，再转与车身垂直部位，用锁紧装置把卸料溜槽和加长溜槽锁紧在机架上，防止由于不固定而摇动，造成伤人事故和影响其它车辆运行。
5. When driving on the highway, the extended chute shall be turned over and placed on the unloading chute, hung firmly with a hook, and then turned to the position perpendicular to the vehicle body. The unloading chute and the extended chute shall be locked on the frame with a locking device to prevent shaking due to instability, causing personal injury accidents and affecting the operation of other vehicles.
6、车穿越桥、洞、库等设施时，须注意通过高度的尺寸及路面承受重量以免损坏搅拌车。
6. When the truck passes through bridges, holes, warehouses and other facilities, pay attention to the size of passing height and the weight borne by the road surface to avoid damaging the mixer truck.
7、工作装置连续运转时间不应超过8h。
7. The continuous operation time of the working device shall not exceed 8h.
8、交货时，如发现水分蒸发，塌落度偏低不能满足用户要求时，可适当向筒内加水，然后以12—14r/min的速度旋转30转后卸料。
8. During delivery, if it is found that the water evaporates and the slump is too low to meet the user's requirements, add water to the cylinder appropriately, and then rotate for 30 revolutions at the speed of 12-14r / min before unloading.
9、搅拌车在空载运行及运送混凝土过程中，搅拌筒不得停止转动以免滚道、滚轮局部碰损或混凝土产生离析现象。
9. During the no-load operation and concrete transportation of the mixer truck, the mixing drum shall not stop rotating, so as to avoid local collision damage of the raceway and roller or segregation of the concrete.
10、水箱的水量要经常加满，以备急用。
10. The water tank should always be filled up for emergency use.
11、水箱加水前，须打开放气阀把箱内空气放掉，充气供水后须及时关闭贮气筒。
11. Before adding water to the water tank, the vent valve must be opened to release the air in the tank. After inflating and supplying water, the air reservoir must be closed in time.
注意：水箱仅在供水时加压,不要带着加压水箱在公路上行驶
Note: the water tank is pressurized only when supplying water. Do not drive on the road with the pressurized water tank
以上就是小编为您提供的关于自上料搅拌车厂家 的知识，更多的精彩内容请您继续关注我们的网站：https://www.jfjiaobanche.com，我们会有更多对的精彩内容 为您分享.
The above is the knowledge about the manufacturer of self loading mixer truck provided by Xiaobian. Please continue to pay attention to our website for more wonderful contents: https://www.jfjiaobanche.com , we will have more wonderful content for you to share
下一篇：小型混凝土搅拌车在工作时要注意容量？上一篇：检查搅拌车磨损你有哪些技巧？
