中科聚峰

自上料搅拌车行业持续领跑者!

品质创造未来,让世界爱上中科聚峰造

全国咨询热线
400-879-1999

产品推荐

0.5方自上料搅拌机
0.5方自上料搅拌机
产品介绍:
1.2方自上料搅拌机
1.2方自上料搅拌机
产品介绍:产品型号:JBC-1...
1.8方自上料搅拌机
1.8方自上料搅拌机
产品介绍:参数说明轴距:2...
2.6方自上料搅拌机
2.6方自上料搅拌机
产品介绍:参数说明轴距:2...
2.6同步旋转自上料搅拌机
2.6同步旋转自上料搅拌机
产品介绍:参数说明轴距:2...
2方后置驾驶室自上料搅拌机
2方后置驾驶室自上料搅拌机
产品介绍:参数说明轴距:2...
3.5方D款自上料搅拌机
3.5方D款自上料搅拌机
产品介绍:参数说明轴距:2...
3.5方C款自上料搅拌机
3.5方C款自上料搅拌机
产品介绍:参数说明轴距:2...
3.5方B款自上料搅拌机
3.5方B款自上料搅拌机
产品介绍:参数说明轴距:2...
3.5方A款自上料搅拌机
3.5方A款自上料搅拌机
产品介绍:参数说明轴距:2...
4.0方自上料搅拌机
4.0方自上料搅拌机
产品介绍:参数说明轴距:2...
4方同步旋转自上料搅拌机
4方同步旋转自上料搅拌机
产品介绍:参数说明轴距:3...
5.5方自上料搅拌机
5.5方自上料搅拌机
产品介绍:参数说明轴距:3...
6.5方自上料搅拌机
6.5方自上料搅拌机
产品介绍:参数说明轴距:2...

资讯推荐

当前位置:首页 »中科搅拌机新闻 » 新闻资讯 » 中科聚峰搅拌车罐子不转如何应对?

中科聚峰搅拌车罐子不转如何应对?

来源:https://www.jfjiaobanche.com 浏览:发表时间:2020-09-07
  前不久有用户来电说“我搅拌车开在路上罐子突然不转了!!咋回事儿?”他说他的搅拌车装载了混凝土从搅拌站驶出后,罐子突然就停转了,问怎么处理。下面,将给大家好好分析下混凝土搅拌车罐子不转的原因,希望能给以后遇到同样问题的砼行们一个参考处理方案。
  Not long ago, a user called and said, "my blender was driving on the road, and the jar suddenly stopped turning!! What's the matter? " He said his truck was loaded with concrete and drove out of the mixing plant when the tank suddenly stopped and asked what to do with it. Next, we will give you a good analysis of the concrete mixer tank does not turn the reason, hope to be able to encounter the same problem in the future concrete line a reference treatment plan.
  为什么罐子不转了?
  Why doesn't the jar turn?
  一般情况是:
  The general situation is as follows:
  一、检查一下液压油是否漏光了(管子坏了换管子,密封件坏了换密封件)!
  1、 Check whether the hydraulic oil leaks completely (replace the pipe if the pipe is broken, replace the seal if the seal is broken)!
  二、检查一下散热器风扇在转没有,液压油乳化变白没有,液压油温度超过90度,液压系统就没有压力,罐子就不转了!(这种情况不要着急,用水冷却一下液压泵,液压马达,液压油温度下来,罐子就可以转动了。把料放出来,赶紧修理散热器或更换液压油!)
  2、 Check whether the radiator fan is running, whether the hydraulic oil emulsion turns white, if the hydraulic oil temperature exceeds 90 degrees, the hydraulic system will not have pressure, and the tank will not turn! (in this case, don't worry. Cool the hydraulic pump, hydraulic motor and hydraulic oil with water. When the temperature of the hydraulic oil drops, the tank can rotate. Put the material out and repair the radiator or change the hydraulic oil quickly!)
               中科聚峰搅拌车
  三、运输途中没有注意,罐子停了!混凝土塌住了,罐子翻不过去!(感觉有压力能转一点就可能是这种情况)
  3、 Didn't pay attention during transportation, the jar stopped! The concrete caved in and the jar couldn't be turned over! (this may be the case if you can turn a little under pressure.)
  四、发动机故障(不可能哦,轰隆隆响起在!!)
  4、 Engine failure (impossible, boom in the ring!)
  五、传动轴十字节损坏,断了(a断了立即更换一根传动轴;b传动轴好的);
  5、 The cross section of transmission shaft is damaged and broken (a is broken, replace a transmission shaft immediately; B drive shaft is good);
  六、液压泵损坏了(情况复杂一点,内泻严重,其他损坏);
  6、 The hydraulic pump is damaged (the situation is a little more complicated, the internal leakage is serious, and other damages are caused);
  以上六种情况出现,且混凝土没有凝结,液压马达、减速机没有故障,可以使用应急装置,用另一辆搅拌车的液压泵带动液压马达转动罐子,将混凝土放出,再检修!如何使用应急装置及注意事项,今后会再讲到!!
  If the above six cases occur, and the concrete does not condense, and the hydraulic motor and reducer have no fault, you can use the emergency device, use the hydraulic pump of another mixer to drive the hydraulic motor to rotate the tank, release the concrete, and then overhaul! How to use the emergency device and precautions will be discussed in the future!!
  七、液压马达损坏了!
  7、 The hydraulic motor is damaged!
  八、减速机坏了!!
  8、 The reducer is broken!!
  第七、八两种情况出现,不能使用应急装置!可以将罐体上的检查盖打开将混凝土放出。
  Seven, eight two cases appear, can not use emergency devices! The inspection cover on the tank can be opened to discharge the concrete.
  检查盖在罐体上方怎么办??可以用塔机、卷扬机将罐体检查盖旋转到下方,将混凝土放出;
  What to do if the inspection cover is above the tank body?? The tower crane and winch can be used to rotate the tank body inspection cover to the lower part to release the concrete;
  罐子卡住了旋转不动怎么办?可以在罐体侧下方用气割开一个50厘米见方的孔(注意避开罐里的螺旋叶片,割下的罐壁一定保留,修复起来迅速、方便而且美观),将混凝土放出。
  What can I do if the jar is stuck and can't rotate? A 50 cm square hole can be cut under the side of the tank by gas cutting (pay attention to avoid the spiral blades in the tank, the cut tank wall must be retained, and the repair is fast, convenient and beautiful), and the concrete is discharged.
  罐子不转了,不要惊慌!不要忙乱!
  Don't panic if the jar doesn't turn! Don't be in a hurry!
  坚持一个原则,不要让混凝土凝结在罐子里,清理凝固在搅拌罐里的混凝土是又费时间、又费钱的事!混凝土放出来,你可以从容处理搅拌车的故障!!
  Adhere to a principle, do not let the concrete coagulate in the tank, cleaning the concrete solidified in the mixing tank is time-consuming and money consuming! When the concrete is put out, you can handle the trouble of mixer truck calmly!!
  以上是应对混凝土搅拌车罐子不转的措施,希望对大家有所帮助,如想要了解更多内容欢迎点击中科聚峰搅拌车https://www.jfjiaobanche.com官网。
  The above is to deal with the concrete mixer tank does not rotate measures, I hope to help you, if you want to learn more, welcome to click the Zhongke Jufeng mixer https://www.jfjiaobanche.com Official website.